AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (2023)


Did you know your air conditioner makes about 30 gallons of water each day? It's true, and if you've ever experienced a clogged AC drain that has over-flown into your home's interior you probably have first hand experience with the disaster and damage all that water can create.

AC drain lines can often clog and if your indoor AC unit happens to be located in your attic, then the water created by the AC system begins to over-flow out of the system and naturally drips on to the ceiling below it - Soaking into the sheetrock, staining and ruining the home's interior. If the issue isn't resolved rather quickly the water will easily soak into the sheetrock to the point where it becomes so saturated with water that the sheetrock ceiling falls apart, collapses, and leaks massive amounts of water into the inside of your home where it can damage all of your valuables. This is why drain line maintenance is so important for every home and should be something every homeowner takes very seriously. Lets go over why air conditioners make so much water, where the water is supposed to drain to, how the AC drain lines actually clogs, and what we can do to protect our homes and prevent clogs from ever happening.

"Why do air conditioners make so much water?"

Air conditioners make a lot of water. Well, they don't actually 'make' water - They extract and 'squeeze' water out of the air and since Houston's air is generally very humid, this means our air contains a lot of moisture, which then gets extracted by our air conditioning systems as they operate and cool our homes. The reason air conditioners 'make' or extract so much water is because air conditioners not only cool down the air in our homes, but they also dehumidify the air in our homes by removing moisture from the air, thus lowering the temperature and the humidity within our homes. All of this water the AC system pulls out of the air is then collected in a small drain pan located inside of the air conditioner's indoor evaporator coil section and if the system's drain line isn't clogged the AC system then dumps all of this water it extracts from the drain pan into the drain line and (hopfully) drains the water away into your home's plumbing.

AC drain lines typically tie into the plumbing of a home under a kitchen or bathroom sink, which is a common place where the drain gets clogged due to the drain line changing size and diameter as it connects to the sink. People are also known for plugging up sinks with all sorts of things - So if the sink doesn't drain well, then unfortunately the air conditioning system doesn't drain well. And if the sink is clogged, then the AC system is clogged cannot drain at all and will begin to over-flow.

Some home's take a different approach - Builders have learned that sinks clog frequently so some builders choose to drain the AC system directly into the home's 3 inch plumbing stack located in the attic, and this is great, because it's a lot harder to clog the entire home's plumbing than it is the sink (although it can happen). If you're home's AC system is set up like this, then you're builder did a great job and you'll most likely see clogged AC drain's a lot less frequently than a home that drains the AC system into a sink. Since the AC system is typically located in the attic, it's very close to the plumbing vent that exits through your home's roof and some builders will simply tie the AC drain line into the plumbing vent (which rarely clogs). This means drain lines aren't nearly as long, don't make nearly as many sharp turns, they don't change sizes, and there are just fewer interactions with people and less surface area to clog.

(Video) How to Unclog AC Drain Line Fast (3 Seconds), Avoid Repairman

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (1)

"Why do AC drain lines clog?"

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (2)
AC drain lines generally clog due to the growth and formation of bacteria within the drain line. Very rarely can outside objects get into the closed drain (although I have seen it happen). The cold, damp, and dark environment inside a plastic AC drain line happens to be the perfect breeding ground for bacteria, slime, and sludge. Over time this gunk forms and without proper care and treatment just like you see with a untreated swimming pool, and the AC drain lines soon clog because of the build up of this slime and sludge and it drying and solidifying during the heating season when the drain line isn't being used.

Murphy's law never fails when it comes to AC drain lines - I'm almost positive it states something about how AC drain lines never give warning as to when they plan to clog up and they also tend to clog right at the wrong time. Clogging usually happens when you're not at home or when you are returning home from a week long vacation only to find a disaster waiting for you when you open the front door - The ceiling has collapsed in your living room and your carpet is soaking wet and you gaze up only to see the indoor AC unit still steadily dripping water onto what was once your beautiful living room - Welcome back!


AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (3)

"What can I do to prevent my AC drains from clogging?"

(Video) Why Air Conditioning Ducts, Units, and Vents Sweat

In order to keep the slime and sludge from forming in your AC drain lines you have to keep your drain lines treated with bleach or chlorine tablets just like a pool. Several companies make smaller chlorine tablets specifically designed for this purpose (see below). Some people use liquid bleach as an alternative, but as an air conditioning technician I don't recommend using liquid bleach over the tablets because it is a liquid and naturally it flows right through the drain line and doesn't have enough time to stick around and kill off all the bacteria like a tablet would. Condensate pan tablets dissolve over time as the air conditioner makes water and the tablets melt and coat the drain line thus treating the drain line over a longer period of time and this solution works better when compared to liquid bleach. But if liquid bleach is all you have, then use bleach but make sure you order some tablets off amazon or pick some up at the local home depot.


"Will condensate drain tablets unclog my drain line?"

Condensate tabs or bleach won't clear or unclog your drain lines if they are already clogged or in bad shape. But they will prevent it from clogging.

"How did my drain line get clogged anyway?"

Well, over time and through periods of untreated cooling and heating cycles where air conditioners go from running and making gallons of water a day during the summer, to not running and not making any water during the winter, the drain lines go from being constantly full of water to being bone dry. This process hardens all the built up slime and sludge and solidifies it into a calcium-like solid and becomes almost impossible to clear out. During the next cooling season a new layer of slime and sludge forms over the hardened solidified layer and slowly, layer by layer, season by season, the drain line becomes irreversably clogged. When this happens, it's best to have your drain lines replaced by a professional. You can try replacing the drain lines yourself, but keep in mind that gravity is in charge of draining water away from your AC system so the drains need a steady down-hill slope all the way to the home's plumbing (water doesn't flow up-hill) so the water can flow and wont settle or back up and over-flow out of your AC system. Tip: Always test your drain lines first before turning on the air conditioner and walking away after performing any work on them.

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (4)

(Video) How to clean your central air conditioner drain tube - by John C Flood

"Ok, I have the drain tablets/bleach, where do I put this stuff again?"

In order to add bleach or drain tablets to the system, your first going to have to locate the indoor unit of your air conditioning system, which is usually found in an attic or a closet space. Once the unit is located we now need to find the drain lines, there should be 2 drain lines coming off your AC system, although some systems only have 1 (shown below). Some HVAC systems have a built in accessible area where you can drop the tablets or pour the bleach directly into the drain line (see below) which makes treating drain lines a quick and easy process:

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (5)

However, some systems don't have this "T" shaped tee adapted to the drain line which means you might have to do a little work to get the tablets into the AC drainage system. If this is the case, you have to actually open up the front cover to the evaporator coil which will be screwed shut and may be taped shut. Locate the evaporator coil, this is the component that looks like a box and has a drain line coming out of it, as well as the copper refrigerant lines. Take the tape off the front of the evaporator coil's housing (if there is any), locate the screws that go all around the front cover of the evaporator coil housing, remove the screws, pull off the cover, and once the front cover is off you can drop the tablets into the internal pan located directly underneath the evaporator coil itself, which 95% of the time is going to be made of plastic so don't break it by leaning on the drain line. Make sure you are dropping the tabs or pouring the bleach into the primary internal pan of the system and not the secondary emergency drain pan located outside of the system (which is usually a big pan made of sheet metal).

After you're done treating the drains, make sure to put back all the screws and tape up the front cover when putting it back on in order to prevent air leaks, don't just attempt to tape the door shut for easier access later because the indoor blower motor will blow the door back off if it is not screwed on properly and this will cause more harm than good. Tip: If the cover is left off for too long while the air conditioner is running, the evaporator coil can freeze-up and stop cooling, so try to be quick about treating the drains or turn the system off when doing so if your going to take your time.

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (6)

(Video) Air Conditioner Maintenance Tips

"How often am I supposed to treat my drain lines?"

If your using condensate pan tablets to treat the drains, the manufacturer of the tablet usually lists how many tablets are supposed to be used and how often they are supposed to be added to the system somewhere on the box - It's typically every 3 to 6 months which is why at Adams Air we always clear and treat AC drain lines when we perform our HVAC preventative maintenance tasks. Bleach on the other hand should be added to the system every time you change the air filters during the cooling season, which should be a monthly process.

If you're still concerned about your AC drain lines, an electronic switch called a float switch can also be added to your HVAC system which is a sensor that senses if the water level ever rises to the point where it's about to over-flow. Once the switch senses the water level is too high, it will turn off the air conditioning system which prevents the system from making more water and over-flowing on to your ceiling. This should alert you that there is a problem and at the very least if you happen to be away it ensures that the system isn't going to over-flow. If you notice the AC system isn't running you can then go up to the AC system and check if the drain lines are backed up and if the switch is triggered - If they are, the drains need to be cleared and unclogged. Once cleared and once the water drains away, the switch will notice that the water level has decreased and it will then allow the system to kick back on and cool again. At Adams Air we install these float switches with all of our new HVAC installations and recommend them to all of our clients if their system is without one:

AC Drain Maintenance Tips - Adams Air Houston HVAC Blog (7)

AC drain lines are a pretty serious topic when it comes to an HVAC system because they can cause extensive and expensive water damage to the places we live and work in - Destroying ceilings, furnishings, floors, walls, art, computers, electronics, and more. If your drain line ever does become clogged, you can try cutting it open and clearing it with a wet/shop vac, or blowing it out with compressed air, nitrogen, or with a pump. If your able to get the line cleared and properly draining again, just remember to keep the drains treated more often. If your unable to clear the drains, you're probably going to have to call a professional to attempt to clear them or have them replaced, and remember when attempting to clear your drain lines or replace them on your own, always test your drains with a jug of water and keep a wet vac near by just in case things start to over-flow and get out of control (and they quickly will if you cut them open and they are full of water). Monitor the system for a few hours after turning it back on and just keep an eye out for any water stains on your ceiling below and around the AC system. If you see water stains starting to form on the ceiling, immediately shut the system off and take a wet vac to the drain line and vacuum all the water out of the drain line until you can repair the problem.

If caught early-on a wet ceiling can simply be dried, sanded and repainted. If left too long the sheetrock will absorb too much water and the water will cause the entire section of sheet rock to come crashing down inside your home and then things can start to get expensive. Just be careful when dealing with drainage systems, don't pour drain cleaner down the AC drain line, think twice about how water always flows down-hill and follows the path of least resistance, test and re-test the drain lines with a bucket of water and a funnel, always use PVC glue when re-attaching PVC pipe. Finally, if you ever need assistance clearing your drain lines, replacing your drain lines or any Houston AC repair, the experts at Adams Air are always available to assist.

(Video) Maintaining Your Air Conditioner

FAQs

Is bleach or vinegar better for AC drain line? ›

Cleaning AC Drain Line

We recommend using vinegar instead of a bleach solution because bleach can cause corrosion if you have copper tubing in your AC's drain line. In addition, spilling bleach can ruin your carpet or clothing, whereas vinegar does not harm; it just leaves an odor.

Why does my AC drain keeps clogging? ›

Dust is one of the most common causes of clogged air conditioner drains. As such, you must clean or replace your AC air filters to prevent dust from building up on the evaporator coils. Do this every few weeks to prevent blockage and keep your AC unit functioning effectively. Flush drain lines.

How much vinegar should I pour down AC drain? ›

Vinegar is one way of easily doing this. By putting a quarter of a cup of distilled vinegar into your air conditioner's drain line, the vinegar kills mold, mildew, algae, fungus and bacteria. It'll clear buildups and clogs. You should clean a drain line once a month.

How do I stop my AC drain from sludge? ›

To prevent white slime from building up:

Change your AC filter regularly. When your filter is clogged, the unfiltered dust and dirt collect on the coil and become food for bacteria. Ask your HVAC technician for tips on how to keep the drain line clean between routine maintenance visits.

What is best to clean AC drain line? ›

The easiest way to clean drain lines is with a bit of bleach or vinegar. It only takes 5-10 minutes to clean your system and remove any mold or mildew, and when you're done you will be able to use your AC system even better than before!

Does vinegar damage drain pipes? ›

The answer is that vinegar will not harm your pipes if used in small doses as recommended in many of the recipes that you find online. No matter what your pipes are made of, pex, pvc, copper, etc. Vinegar will not harm your water pipes.

Can you snake an AC drain line? ›

You can snake a clogged A/C drain line to remove blockages. Traditional plumbing snakes usually cannot navigate the 90* turns of PVC elbows, but a smart snake can. Be careful when snaking the drain that you do not push the clog farther down the line.

How do I know if my AC drain line is clogged? ›

A clogged AC drain line symptoms include:
  1. Musty, moldy smell near your indoor unit or in air from the registers/vents.
  2. Standing water near the indoor unit.
  3. Water damage in areas near the indoor unit.
  4. AC system is not cooling your home.
  5. AC system shuts down or doesn't turn on.

How do you unclog an HVAC drain? ›

How to UNCLOG your AC DRAIN Condensate line FAST - YouTube

Where do I pour vinegar in my AC unit? ›

All it takes is 1/4 cup of vinegar, and a couple minutes of your time:
  1. Find your drain line. It should be near your drain pan, located near the air handler. ...
  2. Remove the cap.
  3. Pour in 1/4 cup of distilled vinegar. ...
  4. Place the cap back on the drain line.
Jun 1, 2016

How long does it take for vinegar to unclog AC drain? ›

Let the solution sit for 30 minutes.

Flush the pipe out with water to ensure everything is flowing freely and operating as it should.

Can I put vinegar in my condensate pump? ›

What chemical should I pour down the condensate drain? We recommend at least four times a year to pour a one-fourth to one-half cup of plain, white vinegar in your condensate drain. Don't use bleach as it can spill onto your metal drain pan and react with the metal, causing problems later on.

How often should I put bleach in my AC drain? ›

Using Bleach in Your AC Drain

Be sure to use a minimum of 2 cups once or twice per year. Be advised, however, some newer units no longer recommend bleach or vinegar due to oxidation/degradation concerns. In these cases, boiling water is recommended.

What is white slime in AC drain line? ›

Bacteria (white slime):

A symptom of bacteria run amuck is your a/c system not cooling. Bacteria grows and it travels up your condensate drain line into your air handler unit. This bacteria clings to the side of the drain pipe and starts to grow in long, slimy tendrils.

Do AC drain pan tablets work? ›

"Will condensate drain tablets unclog my drain line?" Condensate tabs or bleach won't clear or unclog your drain lines if they are already clogged or in bad shape. But they will prevent it from clogging.

Should I put bleach in my AC drain line? ›

The reason you shouldn't use bleach or vinegar to clean your AC drain line all boils down to the fact that these chemicals are corrosive to metals. In other words, they literally eat away at metal.

Can I put bleach in my condensate pump? ›

Sometimes it has a cap on it and sometimes it is just open to the drain. Put a funnel in the "T" and pour a quart or two of bleach into the drain. Go slowly as to allow the bleach to kill the mold and mildew . This should be done once a year at least.

How do I put vinegar in my AC drain line? ›

Cleaning Your AC Drain Line Using Vinegar in 3 Steps
  1. Locate the Drain Line. The condensate drain is a PVC pipe typically located outside near the compressor, attached to a wall of your home. ...
  2. Pour in the Vinegar. Remove the drain line plug and pour in ¼ cup of distilled vinegar. ...
  3. Repeat Monthly.
Jul 17, 2015

Can you leave baking soda and vinegar in drain overnight? ›

If it's still clogged, pour one cup of baking soda and one cup of vinegar down the drain, followed by two cups of boiling water. Let it work overnight to clear the drain.

Is baking soda bad for drains? ›

While the baking soda and vinegar solution is effective in breaking down a clog, it will also cause your drain to become more damaged. The baking soda's abrasive nature will wear down your drain over time. This is why you should avoid using baking soda and vinegar solution for cleaning out your drain.

Why pour peroxide down drain? ›

Hydrogen peroxide dissolves organic matter to loosen and flush away debris such as skin cells. It also disinfects the drain as it works by reducing germs inside your pipes and making your sinks smell fresh and clean. To use hydrogen peroxide on a clogged drain, look for a 3% hydrogen peroxide formula.

How much water should drain from an air conditioner? ›

When the summer season is in full swing and humidity is high, it's normal for your air conditioner to drain anywhere between 5 and 20 gallons of water each day.

How do you test a condensate drain line? ›

Use a flashlight to inspect the drain pan, located inside the air handler. Check the opening to the condensate drain line for any obvious backups or debris. Clean out the drain pan as best you can. If there is condensate in the overflow pan, you probably have drain line clog.

What happens if HVAC drain is clogged? ›

A Clogged Line Will Freeze Your AC System

A clogged condensate drain line will trap water in your air conditioner. As a result, the evaporator coil will eventually turn to ice. The moisture in the drain line can also freeze, which will cause your air conditioner to turn off.

Can you put bleach in AC drain pan? ›

It's going to corrode! Using bleach or vinegar can be especially risky if you think your AC drain line is clogged. If the drain line is clogged, the corrosive mixture will simply back up in your drain line and flow into your drain pan, which in turn can damage your evaporator coil.

How often should you pour bleach in AC drain? ›

Using Bleach in Your AC Drain

Be sure to use a minimum of 2 cups once or twice per year. Be advised, however, some newer units no longer recommend bleach or vinegar due to oxidation/degradation concerns. In these cases, boiling water is recommended.

Will vinegar hurt evaporator coils? ›

White vinegar offers natural disinfecting properties that help disrupt current mold and bacteria growth while preventing future growth from occurring. Allow the solution to sit on the evaporator coil for a few minutes and then rinse it off with distilled water.

How do you clean a HVAC drain line? ›

How to UNCLOG your AC DRAIN Condensate line FAST - YouTube

Videos

1. How to Clean An Air Conditioner Unit
(Ingram's Water and Air Equipment)
2. BOGO HVAC Sale - The Last System You'll Ever Have to Buy!
(Anderson Plumbing, Heating & Air)
3. How to Clean an Air Conditioner Indoor Air Handler and Condensation Drain
(Kalos Services Inc.)
4. How Air Conditioning Was Invented: A True "Florida Man" Story from SVN Saunders Ralston Dantzler
(SVN Saunders Ralston Dantzler Real Estate)
5. Failed Condensate Pump flooded Basement
(aaaflooddrying)
6. Always Place A Bag On Your Car Mirror When Traveling Alone, Here’s Why !
(Did You Know ?)
Top Articles
Latest Posts
Article information

Author: Arline Emard IV

Last Updated: 02/09/2023

Views: 6022

Rating: 4.1 / 5 (72 voted)

Reviews: 87% of readers found this page helpful

Author information

Name: Arline Emard IV

Birthday: 1996-07-10

Address: 8912 Hintz Shore, West Louie, AZ 69363-0747

Phone: +13454700762376

Job: Administration Technician

Hobby: Paintball, Horseback riding, Cycling, Running, Macrame, Playing musical instruments, Soapmaking

Introduction: My name is Arline Emard IV, I am a cheerful, gorgeous, colorful, joyous, excited, super, inquisitive person who loves writing and wants to share my knowledge and understanding with you.